Analysis of car waste heat recovery system utilizing thermoelectric generator

Analiza systemu wykorzystującego generator termoelektryczny do odzysku ciepła odpadowego z samochodu

  • Artur Nemś Wroclaw University of Science and Technology, Faculty of Mechanical and Power Engineering
  • Mikołaj Simiński Wroclaw University of Science and Technology, Faculty of Mechanical and Power Engineering
  • Magdalena Nemś Wroclaw University of Science and Technology, Faculty of Mechanical and Power Engineering
  • Tomasz Magiera Wroclaw University of Science and Technology, Faculty of Mechanical and Power Engineering
Keywords: car, thermoelectric generator, heat recovery, waste heat, exhaust system, engine

Abstract

This paper presents a calculation algorithm for a thermoelectric generator fitted in the exhaust system of a combustion engine. The viability of the presented calculation method was verified on an actual combustion engine. The calculations were performed for a BMW engine, and the generator design was based on a prototype from the same manufacturer. The paper includes calculations of the thermal cycle and of the parameters of exhaust gases from the engine. Subsequent calculations cover heat transfer from exhaust gases to the thermoelectric module and the amount of electric energy obtained from a series of modules. In the last part, the focus is on the influence of engine speed on the performance of the thermoelectric generator.

References

1. A. F. Ioffe, Semiconductor Thermoelements and Thermoelectric Cooling, Infosearch, London 1957.
2. A. Kowalewicz, Podstawy procesów spalania [Basics of combustion processes], Wydawnictwa Naukowo-Techniczne Warszawa 2000
3. A. Skoczylas, Przenoszenie ciepła [Heat transfer], Oficyna Wydawnicza Politechniki Wrocławskiej, Wrocław 1991.
4. C. Sprouse III, C. Depcik, Review of organic Rankine cycles for internal combustion engine exhaust waste heat recovery, Applied Thermal Engineering 51 (2013) 711-722
5. D. Champier, Thermoelectric generators: a review of applications, Energy Conversion and Management 140 (2017) 167–181
6. H. J. Goldsmid, Introduction to Thermoelectricity, Second Edition, Springer Series in Materials Science,DOI 10.1007/978-3-662-49256-7, 2016
7. http://www.customthermoelectric.com/powergen.html (access 06/17/2017)
8. J. A. Wajand, J. T. Wajand, Tłokowe silniki spalinowe średnio i szybkoobrotowe [Medium- and high-speed piston engines], Wydawnictwa Naukowo-Techniczne Warszawa, 2000
9. J. G. Kassakian, Automotive electronics power up, IEEE Spectrum, Vol. 37, Issue: 5, 2000
10. J. Merkisz, P. Fuć, P. Lijewski, Waste energy recovery analysis of a diesel engine exhaust system, in: Heat Transfer XIII: Simulation and Experiments in Heat and Mass Transfer Simulation and Experiments in Heat and Mass, ed. B. Sundén, C.A. Brebbia, WIT Press, New Forest 2014.
11. J. S. Jadhao, D. G. Thombare, Review on Exhaust Gas Heat Recovery for I.C. Engine, International Journal of Engineering and Innovative Technology (IJEIT) Volume 2, Issue 12, June 2013
12. K. Glück: Zustands- und Stoffwerte. Wasser. Dampf. Luft. Verbrennungsrechnung. Verlag für Bauwesen GmbH. Berlin, 1991.
13. K. Jeżowiecka-Kabsch, H. Szewczyk, Mechanika Płynów [Fluid mechanics], Oficyna Wydawnicza Politechniki Wrocławskiej, Wrocław 2001.
14. K.T. Wojciechowski, J. Merkisz, P. Fuc, J. Tomankiewicz, et al., Prototypical thermoelectric generator for waste heat conversion from combustion engines, Combustion Engines No. 3/2013 (154)
15. Koot M., Kessels, J.T.B.A., Energy management for vehicle power nets, de Jager, Bram, van den Bosch, P.P.J. Technische Universiteit Eindhoven, The Netherlands 2004
16. M. Gieras, Spalanie – wybrane zagadnienia w zadaniach [Burning - selected issues in tasks], Oficyna Wydawnicza Politechniki Warszawskiej, Warszawa 2011
17. P. Fuć, Badania termodynamiczne odzysku odpadowej energii gazów spalinowych z użyciem generatora TEG, raport końcowy projektu nr UMO-2011/01/B/ST8/07241 [Thermodynamic studies of waste gas energy recovery using a TEG generator, final report of the project no UMO-2011/01/B/ST8/07241], 2011–2012.
18. R. Jakubowski, Jak oszczędzać prąd w samochodzie? [How to save electricity in the car?] http://mojafirma.infor.pl (access 06/17/2017)
19. The thermoelectric generator from BMW is making use of waste heat, BMW AG, MTZ 04/2009 vol.70
Published
2018-06-21
Section
Eksploatacja i Testy/Exploitation and Tests